不同碱液单晶硅表面织构的初步研究(英文)

CORC > 厦门大学 > 2008年第14卷

	不同碱液单晶硅表面织构的初步研究(英文); Study on the Texturization of c-Si Wafers by Different Kinds of Alkaline for Heterojunction Solar Cells
	豆玉华 ; 周玉琴 ; 朱美芳 ; 宋爽 ; 刘丰珍 ; 刘金龙 ; 张占军 ; DOU Yu-hua ; ZHOU Yu-qin ; ZHU Mei-fang ; SONG Shuang ; LIU Feng-zhen ; LIU Jin-long ; ZHANG Zhan-jun
刊名	http://electrochem.xmu.edu.cn/CN/abstract/abstract8574.shtml
	2008-11-28
关键词	单晶硅织构碱液反射率表面形貌 crystalline silicon texturization alkaline reflectance surface morphology
英文摘要	分别以氢氧化钠(NaOH)、碳酸钠(Na2CO3)和磷酸钠(Na3PO4.12H2O)作为刻蚀剂,研究刻蚀浓度、温度(θ)、刻蚀时间(te)和添加剂(异丙醇(IPA)、碳酸氢钠(NaHCO3))对晶体硅表面织构化的影响,用场发射扫描电子显微镜表征织构效果.通过优化工艺,可得到较低的平均表面反射率(Rav),按使用的刻蚀剂分别为:9.70%(NaOH)、9.76%(Na2CO3)和8.63%(Na3PO4.12H2O).据此分析了Rav和织构表面形貌之间的关系.发现添加剂IPA在Na3PO4.12H2O或Na2CO3与NaOH 3种刻蚀剂溶液中均可明显起改善织构效果.NaHCO3在某些方面具有与IPA的相同作用,同时又能促进大金字塔的形成.文中同时初步提出有关刻蚀过程的机理.; The texturization of(100) crystalline silicon(c-Si) wafer was studied by field-emission scanning electron microscope using different kinds of etchant: sodium hydroxide,sodium carbonate and tribasic sodium phosphate.By optimizing the etching parameters,the lowest values of averaged reflectance(Rav) were obtained to be 9.70% for NaOH,9.76% for Na2CO3 and 8.63% for Na3PO4·12H2O,which is comparable to that of the wafer with textured surface covered with an anti-reflection coating of either silicon nitride or thermally grown silicon dioxide.The relation of Rav and surface morphology of textured wafer was analyzed.Moreover,special emphasis was put on the role of isopropyl alcohol(IPA) and sodium bicarbonate for texturization.It is proved that IPA decreased the etching rate but improved the morphology of the textured surface.It seems that played NaHCO3 played the similar role of IPA but resulted in the formation of large pyramid.The mechanism of texturization by different kinds of etchant was suggested.; 作者联系地址：中国科学院研究生院;北京太阳能研究所;; Author's Address: 1.Graduate University of the Chinese Academy of Sciences,Beijing 100049,China;2.Beijing Solar Energy Institute,Beijing 100083,China
语种	中文
出版者	厦门大学《电化学》编辑部
内容类型	期刊论文
源URL	[http://dspace.xmu.edu.cn/handle/2288/58124]
专题	2008年第14卷
推荐引用方式 GB/T 7714	豆玉华,周玉琴,朱美芳,等. 不同碱液单晶硅表面织构的初步研究(英文), Study on the Texturization of c-Si Wafers by Different Kinds of Alkaline for Heterojunction Solar Cells[J]. http://electrochem.xmu.edu.cn/CN/abstract/abstract8574.shtml,2008.
APA	豆玉华.,周玉琴.,朱美芳.,宋爽.,刘丰珍.,...&ZHANG Zhan-jun.(2008).不同碱液单晶硅表面织构的初步研究(英文).http://electrochem.xmu.edu.cn/CN/abstract/abstract8574.shtml.
MLA	豆玉华,et al."不同碱液单晶硅表面织构的初步研究(英文)".http://electrochem.xmu.edu.cn/CN/abstract/abstract8574.shtml (2008).