QQ客服 官方微博 反馈留言

	双振子自走型直线超声电机的研究
	鹿存跃 ; 魏燕定 ; 郭吉丰 ; 胡金云 ; 黎金良 ; LU Cun-yue ; WEI Yan-ding ; GUO Ji-feng ; HU Jin-yun ; LI Jin-liang
	2010-06-07 ; 2010-06-07
关键词	直线超声电机 压电陶瓷 弯曲振动 共振模态 超声振动 linear ultrasonic motor piezoelectric ceramic bending vibration resonant mode ultrasonic vibration TM359.9
其他题名	Self-driving linear ultrasonic motor with double vibrators
中文摘要	设计了一种双振子自走型直线超声电机,电机的定子由2个同轴的对称布置的弯曲摇头型振子和中部带细颈的柔性振动块组成.2个振子的弯曲振动会激励出中间振动块的摇头振动,使驱动头上的质点产生椭圆运动轨迹,与导轨摩擦接触产生自走直线运动.测量得到定子上振动块的局部弯曲共振频率为20792 Hz,定子的弯曲共振频率约为40420 Hz.仿真发现,以振动块的局部弯曲共振模态作为工作模态能够得到更大的振幅.实验结果表明,在该模态频率下,电机可以提供较大的驱动速度,发热很少,较长时间工作仍旧稳定可靠,故被选作工作模态.在40420 Hz附近电机能够驱动,但是振子发热严重,不易稳定工作.当两相驱动信号的频率为20.8 kHz、相位差为90°、驱动信号电压的峰峰值为138 V时,电机的驱动速度达到598 mm/s,电机的最大驱动力达到1.94 N.; A self-driving linear ultrasonic motor with double vibrators was developed.The stator consists of two vibrators and a mass.The mass is in the middle of the stator.Each vibrator is symmetrically connected with one side of the mass by a slender shaft.The bending vibrations of two vibrators inspire a wobbling motion of the mass.Therefore,the locus of particles on the driving head is an ellipse.The friction force between the mass and the leader drives the motor moving itself.The measured local bending resonant frequency of the mass is about 20 792 Hz,and that of the stator is about 40 420 Hz.Emulation results showed that when the local bending resonant mode of the mass is used as working mode,the vibration amplitude of the mass is large.Experimental results showed that the driving speed of the motor is high and the motor can work stably with little temperature rise when the mass working in the local bending resonant mode.But when the bending resonant mode of the stator is used as working mode,the temperature rise of the stator is high,therefore the motor cannot work stably.The characteristics of the prototype motor were measured experimentally.The maximum speed of the motor is about 598 mm/s,and the maximum driving force is over 1.94 N,when the phase difference of the applied two signals is 90� and the peak to peak driving voltage is 138 V at the frequency of 20.8 kHz.; 国家自然科学基金资助项目(10874152); 浙江省自然科学基金资助项目(Y7080361); 中国科学院声场声信息国家重点实验室开放基金资助项目(200706)
语种	中文 ; 中文
内容类型	期刊论文
源URL	[http://hdl.handle.net/123456789/40975]
专题	清华大学
推荐引用方式 GB/T 7714	鹿存跃,魏燕定,郭吉丰,等. 双振子自走型直线超声电机的研究[J],2010, 2010.
APA	鹿存跃.,魏燕定.,郭吉丰.,胡金云.,黎金良.,...&LI Jin-liang.(2010).双振子自走型直线超声电机的研究..
MLA	鹿存跃,et al."双振子自走型直线超声电机的研究".(2010).

个性服务

查看访问统计

相关权益政策

暂无数据

收藏/分享

除非特别说明，本系统中所有内容都受版权保护，并保留所有权利。